Tweet
Custom Search
TM-55-1905-219-14-3
OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT
OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT
LANDING CRAFT UTILITY
WARNING DEATH
WARNING DEATH-cont.
WARNING DEATH-cont.
WARNING DEATH-cont.
LANDING CRAFT UTILITY
CHAPTER 3 OPERATOR MAINTENANCE INSTRUCTIONS
PRELIMINARY SERVICING OF EQUIPMENT
Central Hydraulic System, Lines and Fittings
INSTALLATION OF SEPARATELY PACKED COMPONENTS
INSTALLATION OF SEPARATELY PACKED COMPONENTS
SYMPTOM INDEX
SYMPTOM INDEX-cont.
SYMPTOM INDEX-cont.
BOW RAMP WINCH
Abnormal Engine Operation
Low Oil Pressure
MARINE GEAR
HYDROSTARTER
REMOTE MAGNETIC HEADING SYSTEM
STEERING CONTROL PANEL
Table 3-1. Propulsion Engine - Exhaust Smoke Analysis -Troubleshooting
c
Table 3-1. Propulsion Engine - Exhaust Smoke Analysis - Troubleshooting (Cont).
Table 3-1. Propulsion Engine - Exhaust Smoke Analysis - Troubleshooting (Cont).
Table 3-1. Propulsion Engine - Exhaust Smoke Analysis - Troubleshooting (Cont).
Table 3-1. Propulsion Engine - Exhaust Smoke Analysis - Troubleshooting (Cont).
Table 3-1. Propulsion Engine - Exhaust Smoke Analysis - Troubleshooting (Cont).
Table 3-2. Propulsion Engine - Hard Starting Troubleshooting (Cont).
Table 3-2. Propulsion Engine - Hard Starting Troubleshooting (Cont).
Table 3-2. Propulsion Engine - Hard Starting Troubleshooting (Cont).
Table 3-2. Propulsion Engine - Hard Starting Troubleshooting (Cont).
Table 3-2. Propulsion Engine - Hard Starting Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-3. Propulsion Engine - Abnormal Engine Operation Troubleshooting (Cont).
Table 3-4. Propulsion Engine - No Fuel or Insufficient Fuel Troubleshooting
Figure 3-1. Fuel System Piping
Table 3-4. Propulsion Engine - No Fuel or Insufficient Fuel Troubleshooting-cont.
Table 3-4. Propulsion Engine - No Fuel or Insufficient Fuel Troubleshooting-cont.
Table 3-4. Propulsion Engine - No Fuel or Insufficient Fuel Troubleshooting-cont.
Table 3-4. Propulsion Engine - No Fuel or Insufficient Fuel Troubleshooting-cont.
Table 3-5. Propulsion Engine - High Lubricating Oil Consumption Troubleshooting
Table 3-5. Propulsion Engine - High Lubricating Oil Consumption Troubleshooting-cont.
Table 3-5. Propulsion Engine - High Lubricating Oil Consumption Troubleshooting-cont.
Table 3-6. Propulsion Engine - Excessive Crankcase Pressure Troubleshooting
Table 3-6. Propulsion Engine - Excessive Crankcase Pressure Troubleshooting-cont.
Table 3-6. Propulsion Engine - Excessive Crankcase Pressure Troubleshooting-cont.
Table 3-7. Propulsion Engine - Low Oil Pressure Troubleshooting. (Cont).
Table 3-7. Propulsion Engine - Low Oil Pressure Troubleshooting. (Cont).
Table 3-7. Propulsion Engine - Low Oil Pressure Troubleshooting. (Cont).
Table 3-8. Propulsion Engine - Abnormal Engine Coolant Operating Temperature Troubleshooting
Table 3-8. Propulsion Engine - Abnormal Engine Coolant Operating Temperature Troubleshooting-cont.
Table 3-9. Propulsion Engine - Low or High Exhaust Valve Opening Pressure Troubleshooting (Cont).
Table 3-10. Marine Gear Troubleshooting
Table 3-10. Marine Gear Troubleshooting (Cont).
Table 3-10. Marine Gear Troubleshooting (Cont).
Table 3-10. Marine Gear Troubleshooting (Cont).
Table 3-11. Hydrostarter - Low or No Accumulator Pressure - Troubleshooting.
Table 3-11. Hydrostarter - Low or No Accumulator Pressure - Troubleshooting (Cont)
Engine driven pump fails to raise pressure
Engine driven pump fails to raise pressure (Cont)
Table 3-12. Hydrostarter - Cranking Speed Too Low - Troubleshooting
Cranking speed too low
Loss of fluid from reservoir
Loss of fluid pressure when engine is not running
Loss of fluid pressure when engine is not running (Cont).
Table 3-15. Hydrostarter - Hand Pump Fails to Discharge Fluid - Troubleshooting
Hand pump fails to discharge fluid
Table 3-16. Hydrostarter - Starter Turns but Engine Does Not - Troubleshooting
Table 3-17. Hydrostarter - Loss of Accumulator Precharge (Nitrogen) - Troubleshooting
Table 3-18. Hydrostarter - High Pressure in System (3500 psi or above) - Troubleshooting
Table 3-20. Hydrostarter - Fluid Emerges Around Rubber Boot of Hand Pump - Troubleshooting.
Table 3-22. Generator Engine - Exhaust Smoke Analysis - Troubleshooting
Black or grey smoke observed
Black or grey smoke observed (Cont).
Black or gray smoke caused by excessive fuel
Black or gray smoke caused by improper grade of fuel
Table 3-23. Generator Engine - Hard Starting - Troubleshooting
Low cranking speed
Low compression
Inoperative starting aid at low ambient temperature
Table 3-24. Generator Engine - Abnormal Engine Operation troubleshooting
Uneven running or frequent stalling
Uneven running or frequent stalling (Cont).
Lack of power
Lack of power (Cont).
Lack of power (Cont).
Lack of power (Cont).
Lack of power (Cont).
Detonation
Detonation (Cont).
Detonation (Cont).
Table 3-25. Generator Engine - No Fuel or Insufficient Fuel troubleshooting
Air leaks
Faulty fuel pump
Faulty installation
Faulty installation (Cont).
Table 3-26. Generator Engine - High Lubricating Oil Consumption troubleshooting
Oil control at cylinder
Table 3-27. Generator Engine - Excessive Crankcase Pressure -Troubleshooting
Air from blower or air box
Table 3-28. Generator Engine - Low Oil Pressure - Troubleshooting
Poor circulation
Pressure gage and alarm switch
Oil pump
Table 3-29. Generator Engine - Abnormal Engine Coolant Operating. Temperature Troubleshooting (Cont).
Table 3-30. Generator Engine - Low or High Exhaust Valve Opening. Pressure Troubleshooting.
Table 3-31. Hydrostarter - Low or No Accumulator Pressure - Troubleshooting.
Engine driven pump fails to raise pressure
Engine driven pump fails to raise pressure (Cont).
Engine driven pump fails to raise pressure (Cont).
Table 3-32. Hydrostarter - Cranking Speed Too Low - Troubleshooting.
Cranking speed too low
Table 3-33. Hydrostarter - Loss of Fluid from Reservoir - Troubleshooting.
Table 3-34. Hydrostarter - Loss of Fluid Pressure When Engine is Not Running - Troubleshooting.
Loss of fluid pressure when engine is not running
Table 3-35. Hydrostarter - Hand Pump Fails to Discharge Fluid - Troubleshooting.
Hand pump fails to discharge fluid
Hand pump fails to discharge fluid (Cont)
Table 3-36. Hydrostarter - Starter Turns but Engine Does Not- Troubleshooting.
Table 3-37. Hydrostarter - Loss of Accumulator Precharge (Nitrogen) - Troubleshooting.
Table 3-38. Hydrostarter - High Pressure in System (3500 psi or above) - Troubleshooting.
Table 3-40. Hydrostarter - Fluid Emerges Around Rubber Boot of Hand Pump - Troubleshooting.
Table 3-41. Hydrostarter - Fluid Emerges From Ends of Starter Control Valve When Starter Is Operated - Troubleshooting.
Table 3-42. Generator - Troubleshooting. of Hand Pump - Troubleshooting.
Table 3-43. Switchboard Troubleshooting.
Starter cranks generator but stops when start switch is released
Generator fails to supply power to switchboard
Voltmeter reading too high or too low
Generator frequency meter fails to read
Shore power not available
Table 3-44. 24VDC Rectifier Troubleshooting
Batteries not charged
Table 3-45. Bow Ramp Winch Troubleshooting
Motor does not start
Motor runs - shaft does not turn
Table 3-46. Bow Ramp Winch Brake Troubleshooting
Brake does not stop
Manual release does not work
Motor starts but does not come up to speed
Noisy (mechanically)
Table 3-48. Anchor Winch - Winch Troubleshooting.
Drive brake - slipping.
Drive gear
Table 3-49. Anchor Winch Slack Puller Troubleshooting.
Inoperative
Table 3-50. Anchor Winch Disconnect Clutch Troubleshooting.
Table 3-51. Anchor Winch Torque Converter Troubleshooting.
Loss of fluid from converter
Loss of fluid from converter-cont.
Loss of fluid from converter (Cont.).
Loss of fluid from converter (Cont.).
Poor performance and overheating of converter.
Poor performance and overheating of converter (Cont).
Poor performance and overheating of converter (Cont).
Low output horsepower
Excessive pressure
Table 3-52. Anchor Winch - Hydraulic Tank Balanced Piston Relief Valves Troubleshooting (Cont).
Table 3-53. Anchor Winch - Hydraulic Tank Check Valves Troubleshooting.
Table 3-54. Anchor Winch - Hydraulic Tank Pressure Control Valves Troubleshooting.
Excessive noise or chatter
Table 3-55. Anchor Winch Hydraulic Tank Pressure Reducing Valves Troubleshooting (Cont).
Table 3-56. Anchor Winch Hydraulic Tank Directional Control Valve Troubleshooting.
Table 3-57. Anchor Winch Hydraulic Tank Troubleshooting.
Poor performance
Table 3-58. Anchor Winch Hydraulic Pump - Troubleshooting
Table 3-59. Anchor Winch Engine - Exhaust Smoke Analysis - Troubleshooting
Black or grey smoke
Black or grey smoke
Black or gray smoke caused by excessive fuel or irregular fuel distribution
Black Improper grade of fuel
Table 3-60. Anchor Winch Engine - Hard Starting Troubleshooting
Low cranking speed
Low compression
Inoperative starting aid at low ambient temp
Table 3-61. Anchor Winch Engine Abnormal Engine Operation Troubleshooting.
Uneven running or frequent stalling
Lack of power
Lack of power-cont.
Lack of power (Cont).
Lack of power (Cont).
Lack of power (Cont).
Lack of power (Cont).
Detonation
Detonation (Cont).
Table 3-62. Anchor Winch Engine No Fuel or Insufficient Fuel Troubleshooting.
Air leaks
Faulty fuel pump
Faulty installation
Faulty installation (Cont.)
Table 3-63. Anchor Winch Engine High Lubricating Oil Consumption Troubleshooting.
Internal leaks
Table 3-64. Anchor Winch Engine Excessive Crankcase
Breather restriction
Air from blower or air box
Table 3-65. Anchor Winch Engine - Low Oil Pressure - Troubleshooting.
Poor circulation
Oil pump
Table 3-66. Anchor Winch Engine Abnormal Engine Coolant Operating Temperature Troubleshooting.
Temperature below normal
Table 3-67. Anchor Winch Engine Low or High Exhaust Valve Opening Pressure Troubleshooting.
Table 3-68. Anchor Winch Engine - Low or No Accumulator Pressure - Troubleshooting.
Hydraulic Starting System Piping
Engine driven pump fails to raise pressure (Cont.)
Engine driven pump fails to raise pressure (Cont.)
Table 3-69. Anchor Winch Engine - Hydrostarter Cranking Speed Too Low - Troubleshooting.
Table 3-70. Anchor Winch Engine - Hydrostarter - Loss of Fluid From Reservoir - Troubleshooting.
Table 3-71. Anchor Winch Engine - Hydrostarter - Loss of Fluid Pressure When Engine is Not Running - Troubleshooting.
Loss of fluid pressure when engine is not running
Table 3-72. Anchor Winch Engine - Hydrostarter - Hand Pump Fails to Discharge Fluid - Troubleshooting.
Table 3-73. Anchor Winch Engine - Hydrostarter - Starter Turns but Engine Does Not - Troubleshooting.
Table 3-74. Hydrostarter - Loss of Accumulator Precharge (Nitrogen) - Troubleshooting.
Table 3-75. Anchor Winch Engine - Hydrostarter Hight Pressure in System (3500 psi or above) - Troubleshooting.
Table 3-76. Anchor Winch Engine - Hydrostarter Fluid Emerges From the Reservoir Filler Cap When Starter is Used - Troubleshooting.
figure
Table 3-77. Anchor Winch Engine - Hydrostarter Fluid Emerges Around Rubber Boot of Hand Pump - Troubleshooting.
Table 3-78. Anchor Winch Engine - Hydrostarter Fluid Emerges From Ends of Starter Control Valve When Starter Is Operated - Troubleshooting
Table 3-79. Centralized Hydraulic System - Hydraulic Power Unit - Troubleshooting.
Loss of fluid from pump
Loss of fluid from pump
Erratic performance
Table 3-80. Centralized Hydraulic System Controller Troubleshooting
Table 3-81. Stern Gate Hydraulic System - Troubleshooting.
Sluggish operation.
Table 3-82. Mast Hydraulic System - Troubleshooting
Sluggish operation
Table 3-83. "A" Frame Hydraulic Winch - Troubleshooting.
Inoperative
Motor runs but drum does not turn.
Table 3-84. Steering Controller - Troubleshooting.
Hydraulic pump inoperative
Table 3-85. Steering Cub Hydraulic Pump - Troubleshooting.
Steering System Inoperative
Pump making noise
Table 3-86. Steering System - Hydraulic Directional Control Valve Troubleshooting.
Table 3-87. Hydraulic Steering Cylinder and Adjustable Links Troubleshooting.
Table 3-88. Rudder Angle Indicator and Repeatback Transmitter Troubleshooting .
Table 3-89. Heading Selector Troubleshooting.
Table 3-90. Steering Control Panel Troubleshooting.
Inoperative - POWER AVAIL lamps not lit
Automatic steering controls inoperative or erratic
Table 3-91. Remote Magnetic Heading System Troubleshooting
Table 3-92. Ship's Course Indicator Troubleshooting
No response
Indicator does not move freely in gimbals
INDEX
INDEX (Cont)
INDEX (Cont)
INDEX (Cont)
The metric system and equivalents
recommended changes to equipment technical publications
TM-55-1905-219-14-3
blank page
DISTRIBUTION
Privacy Statement
-
Copyright Information.
-
Contact Us
