TB-740-97-4 Preservations of Vessels for Storage Manual

Custom Search

TB-740-97-4

PRESERVATION OF VESSELS FOR STORAGE
PRESERVATION OF VESSELS FOR STORAGE
By Order of the Secretary of the Army:
PRESERVATION OF VESSELS FOR STORAGE - CONTINUED
TABLE OF CONTENS
- BLANK PAGE
TABLE OF CONTENS - CONTINUED
CHAPTER 1 GENERAL
CHAPTER 2 GENERAL INSTRUCTIONS
CHAPTER 2 GENERAL INSTRUCTIONS - CONTINUED
CHAPTER 2 GENERAL INSTRUCTIONS - CONTINUED
CHAPTER 3 STORAGE INSTRUCTIONS
Section II. WET STORAGE
Section II. WET STORAGE - CONTINUED
CHAPTER 4 PRESERVATION INSTRUCTIONS
Table 2. Guide for Protecting Cooling Systems
Combustion Chambers and Values
Compression-ignition engines (diesel and multifuel).
Two cycle engines.
Clutches and Related Components.
Tanks.
Electrical Equipment.
Piping Systems.
Section II. PRESERVATION WITH DYNAMIC DEHUMIDIFICATION (W/O COCOON)
Wet sump
Dry sump.
Combustion Chambers and Valves.
Four cycle, straight diesel or multifuel engines.
Air Cleaners.
Clutches and Related Components.
Electrical Equipment.
Wire Rope, Riggings and Fittings.
Section III. PRESERVATION WITH DYNAMIC DEHUMIDIFICATION WITH COCOON)
Dry sump.
Fuel Systems.
Combustion chambers and valves.
Four cycle, straight diesel or multifuel engines.
Clutches and Related Components.
Electrical Equipment. a. Rotating Electrical Equipment.
Valves
CHAPTER 5 DEPRESERVATION INSTRUCTIONS
CHAPTER 6 DYNAMIC DEHUMIDIFICATION INSTRUCTIONS
Sealing of Dynamic Dehumidification.
Preparation of Zone.
CHAPTER 7 COCOONING INSTRUCTIONS
Figure 1. Relay box, for Multiple D.H. Installation
Figure 2. Relay box cover.
Figure 3A. Air eductor, blower motor.
Figure 3B. Air eductor-air mover ventilator compressed air or steam.
Figure 4. Manometer.
APPENDIX A REFERENCES
APPENDIX A REFERENCES - CONTINUED
APPENDIX B DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR LANDING CRAFT, MECHANIZED, DIESEL, STEEL, 56 FT., MARK VI, DESIGN LCM-6
Preparation for Dynamic Dehumidification.
Figure 5. Dehumidification for craft stored stern to stern.
Figure 6. Dehumidification for craft stored side by side.
Figure 7. Typical cover and stand for dehumidifier
Figure 8. Cab cover.
APPENDIX C DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR LANDING CRAFT, MECHANIZED, DIESEL, STEEL, 69 FT, MARK VIII, DESIGN LCM-8
Cab.
Craft stored side by side (fig. 10).
Figure 9. Dehumidification for craft stored stern to stern.
Figure 10. Dehumidification for craft stored side by side
Figure 11. Typical cover and stand for dehumidifier
Figure 12. Cab cover.
APPENDIX D DYNAMIC DEHUMIDIFICATION INSTRUCTIONS
Preparation for Dynamic Dehumidification.
Dynamic dehumidification installation.
Figure 13. Dehumidification piping zone 1 (BOW) of LCU.
Figure. 14. Dehumidification piping zone 2 (STERN) of LCU.
Figure 15. Typical cover and stand for dehumidifier
Figure 16. Blanks for dehumidification piping for LCU.
APPENDIX E DYNAMIC DEHUMIDIFICATION INSTRUCTIONS
Preparation for Dynamic Dehumidification.
Figure 17. D H piping for tug design 320.
Figure 18. Typical cover and stand for dehumidifier.
APPENDIX F DYNAMIC DEHUMIDIFICATION INSTRUCTIONS
Preparation for Dynamic Dehumidification .
Dehumidification installation .
Figure 19. D.H. piping for tug design 3004.
Figure 20. Dehumidification for tug design 3004.
Figure 21. Typical cover and stand for dehumidifier.
APPENDIX G DYNAMIC DEHUMIDIFICATION INSTRUCTIONS
Preparation for Dynamic Dehumidification .
Dehumidification installation.
Dehumidification installation. - CONTINUED
Figure 22. Dehumidification system No 1 for tug design 3006.
Figure 23. Dehumudification system, No 2 and No 3 for tug design 3(000
Figure 24 Typical cover and stand for dehumidifier.
APPENDIX H DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR BARGE, DECK OR LIQUID CARGO,
Sealing for dehumidification .
Sealing for dehumidification . - CONTINUED
Figure 25. Dehumidification system.
Figure 26. Dehumidification system.
Figure 27. Dehumidification system.
Figure 28. Typical cover and stand for dehumidifier.
Figure 29. Ventilated cover.
APPENDIX I DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR BARGE, LIQUID CARGO,
Boat hook.
Figure.30. Dehumidification system.
Figure 31. Dehumidification system.
Figure 31. Dehumidification system (continued).
Figure 32. Typical cover and stand for dehumidifier.
APPENDIX J DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR LIGHTER, AMPHIBIOUS (LARC-V), SELF-PROPELLER,
Installation of dehumidification system .
Preparation of Rubber Tires for Storage.
Figure 33. Dehumidification system for LARCV design 8005.
Figure 34. Dehumidification system for LARCV design 8005.
Figure 35. Dehumidification system for LARCV design 8005.
Figure 36. Typical cover and stand for dehumidifier.
Figure 37. Bolt on type D.H. stand for LARC V.
APPENDIX K DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR LIGHTER, AMPHIBIOUS (LARC-XV), SELF-PROPELLED,
Installation of dehumidification system.
Preparation prior to placing bag over tire and wheel assembly.
Figure 38. Dehumidification system for LARC XV design 8004.
Figure 39. Dehumidification system for LARC XV design 8004.
Figure 40. Typical cover and stand for dehumidifier.
Figure 41. Bolt on type D. H. stand for LARC XV.
APPENDIX L DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR
Preparation of Rubber Tires for Storage.
Preparation of Rubber Tires for Storage. - CONTINUED
Figure 42. Dehumidification system for LARC LX design 2303.
Figure 43. Typical cover and stand for dehumidifier.
APPENDIX M DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR CRANE, FLOATING, REVOLVING, DIESEL,
Dehumidification installation.
Dehumidification installation. - CONTINUED
Dehumidification installation. - CONTINUED
Figure 44. Dehumidification systems No. 1 and No. 2-design 264B.
Figure 45. Dehumidification systems No. 3 and No. 4-design 264B.
Figure 46. Typical cover and stand for dehumidifier.
DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR CRANE, FLOATING, REVOLVING,
Dehumidification installation.
Figure 47. Dehumidification system No 1
Figure 48. Dehumidification system No. 2
Figure 49. Typical cover and stand for dehumidifier.
APPENDIX O DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR BARGE, REFRIGERATED CARGO,
Dehumidification Installation.
Duct installation No. 2.
Figure 50. Ventilated cover.
Figure 51. Dehumidification system for port engine room.
Figure 52. Typical cover and stand for dehumidifier.
Figure 53. Dehumidification system for refrigerated compartments.
APPENDIX P DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR REPAIR SHOP, FLOATING, MARINE REPAIR,
Dehumidification installation.
Sensing elements.
Figure 54 D.H. piping for main D.H. system, 150,000 CFM machine.
Figure 55 D.H. piping for crane cab
Figure 56 Typical cover and stand for dehumidifier
Figure 57 Fitting for D H piping.
Figure 58 D.H. piping for aft deck house
APPENDIX Q DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR BOAT, PICKET, STEEL, DIESEL ENGINE DRIVEN
Dynamic dehumidification Installation.
Figure 59 Dehumidification, design 4003
Figure 60 Dehumidification, design 4003.
Figure 61 Typical cover and stand for dehumidifier.
APPENDIX R DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR BOAT, UTILITY, DIESEL, 26 FOOT
Dehumidification installation .
Figure 62 Dehumidification system for design 6009
Figure 63 Cockpit cover for design 6009
Figure 64. Typical cover and stand for dehumidifier.
APPENDIX S DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR BOAT, PASSENGER AND CARGO
Sealing for dehumidification .
Crew quarters.
Figure 65. Ventilated cover.
Figure 66. Dehumidification system for Design 2001 (revised).
Figure 67. Typical cover and stand for dehumidifier.
APPENDIX T PRESERVATION AND STORAGE INSTRUCTIONS FOR SELF-ELEVATING BARGES AND PIERS
Preparation Instructions
Figure 68. Typical storage method for self-elevating barges.
APPENDIX U DYNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR TUG, OCEAN GOING,
Sealing for dehumidification .
Dehumidification installation .
Establishment of zones.
Establishment of zones. - CONTINUED
Figure 69. Dehumidification system for tug design 377, using the vessel' fire main (sheet 1 of 2).
Figure 69. Dehumidification system for tug design 377, using the vessel' fire main (sheet 2 of 2).
GENERAL INACTIVATION NOTES
APPENDIX V YNAMIC DEHUMIDIFICATION INSTRUCTIONS FOR VESSEL, LIQUID CARGO,
Dehumidification installation .
Surveillance.
Dynamic dehumidification installation.
Duct Installation.
Figure 70. Dehumidification system for Y-tanker design 294.
Figure 71. Multiple D/H machine hook-up - stacked configuration.
INDEX
INDEX 2
INDEX 3
INDEX 4
RECOMMENDED CHANGE TO EQUIPMENT TECHNICAL PUBLICATION
TB-740-97-4
BLANK PAGE
BLANK PAGE
BLANK PAGE
By Order of the Secretary of the Army: